CARVIN
Войти
Moderate⏱ 30 minutes - 2 hours8 шагов·Оригинал на iFixit ↗

Mercedes-Benz c230 2007 Pull Handle Replacement

A common problem seen in the 2000s Mercedes-Benz is the pull handle breaks off fairly easily with time. This is the full replacement guide for the pull handle of a 2007 Mercedes-Benz c230. The inability to use the pull handle makes it awkward and difficult to close the car door once inside.

This guide can be followed with most Mercedes-Benz models, including: C-Class, W203, C230, C240, C280, C320, C350, C32 AMG, and C55 AMG.

Please make sure to open the window before starting because it will make the steps go by a lot easier.

WARNING: MAKE SURE CAR IS TURNED OFF BEFORE STARTING THE REPLACEMENT

Инструменты (5)

Запчасти (1)

  • APPERFiT Interior Door Pull Handle Gray (Pair) Compatible with Mercedes-Benz C-Class W203 C230 C240 C280 C320 C350 C32 AMG C55 AMG купить ↗

Пошаговая инструкция

Шаг 1 · фото 1Шаг 1 · фото 2Шаг 1 · фото 3
1
  • Use a spudger to pry off the cover of the pull handle.
  • Make sure to lower the window before starting the replacement. In my example, I do it during STEP 4.
Шаг 2 · фото 1Шаг 2 · фото 2Шаг 2 · фото 3
2
  • Use a spudger to pry off the SRS Airbag Badge.
Шаг 3 · фото 1Шаг 3 · фото 2Шаг 3 · фото 3
3
  • Use the [[Item:T30 Torx Driver|T30 Torx Driver|new_window=true]] to remove the two screws located inside the pull handle.
  • Use the [[Item:T30 Torx Driver|T30 Torx Driver|new_window=true]] to remove the screw behind the SRS Airbag Badge.
  • Use the [[Item:T20 Torx Screwdriver|T20 Torx Driver|new_window=true]] to remove the screw on the lock knob.
Шаг 4 · фото 1Шаг 4 · фото 2Шаг 4 · фото 3
4
  • Use the [[Item:Door Upholstery Remover|Door Upholstery Remover|new_window=true]] to pry off the door panel from the metal door frame.
  • After separating the door panel from the metal, gently pull the door panel away from the metal door frame from the sides and bottom to loosen the nails.
  • It would help if the window was down. After opening the window, make sure the car is turned off.
Шаг 5 · фото 1Шаг 5 · фото 2Шаг 5 · фото 3
5
  • Pull the rubber off the wire of the door handle latch cable.
  • Pull off from fasten.
  • Unhook the door handle latch cable
  • BEFORE TOUCHING THE INSIDE OF THE DOOR PANEL, MAKE SURE THE CAR IS TURNED OFF.
Шаг 6 · фото 1Шаг 6 · фото 2
6
  • Use the [[Item:T20 Torx Screwdriver|T20 Torx Screwdriver|new_window=true]] to remove the screws on the pull handle.
Шаг 7 · фото 1Шаг 7 · фото 2Шаг 7 · фото 3
7
  • Use [[Item:Small Flathead Screwdriver|new_window=true]] to press the clips on the side of the pull handle piece.
  • This part of the pull handle is most likely going to be your broken piece, but if not, the piece you will be removing is the top of the pull handle.
  • These are the clips.
Шаг 8 · фото 1Шаг 8 · фото 2Шаг 8 · фото 3
8
  • Place the new [[Item:APPERFiT Interior Door Pull Handle Gray (Pair) Compatible with Mercedes-Benz C-Class W203 C230 C240 C280 C320 C350 C32 AMG C55 AMG|pull handle|new_window=true]] in place.
  • Use the [[Item:T30 Torx Driver|T30 Torx Screwdriver|new_window=true]] to fasten the new [[Item:APPERFiT Interior Door Pull Handle Gray (Pair) Compatible with Mercedes-Benz C-Class W203 C230 C240 C280 C320 C350 C32 AMG C55 AMG|pull handle|new_window=true]].

Завершение

To reassemble your device, follow these instructions in reverse order.

Контент гайда принадлежит iFixit, лицензия CC BY-NC-SA. Открыть оригинал

Mercedes-Benz c230 2007 Pull Handle Replacement — Carvin Garage · Carvin