CARVIN
Войти
Moderate⏱ 1 - 2 hours19 шагов·Оригинал на iFixit ↗

1985-1988 Volvo 740 Brake Pads Replacement

Use this guide to remove, inspect, and replace the rear brake pads. This guide shows you how to remove the brake pads and install new OEM pads. Worn brake pads increase stopping distance and can cause unwanted noise.

Инструменты (4)

Запчасти (1)

Пошаговая инструкция

Шаг 1 · фото 1Шаг 1 · фото 2
1
  • First, disconnect the battery.
  • ***Always*** take the ***negative*** terminal off first, then the positive terminal.
  • ***General Tip***: After disconnecting the battery, let the car sit for about 10 minutes. This will allow any residual energy left in the system to settle and it is good practice for any job you are completing.
Шаг 1 · фото 1
1
  • Turn car off and remove keys from ignition.
  • Place car in park (automatic) or neutral (manual).
  • Engage parking brake.
Шаг 1 · фото 1Шаг 1 · фото 2
1
  • Pry off the front hub caps by placing a small flathead screwdriver between hubcap and rim and pulling the screwdriver and hubcap away from tire.
Шаг 2 · фото 1Шаг 2 · фото 2
2
  • Use hydraulic jack on frame of car to raise car.
  • Place jack head underneath frame couple (pictured).
  • Only necessary to jack the car until the wheels are just off the ground.
Шаг 2 · фото 1
2
  • Loosen each of the five lug nuts on the rear left and rear right tires by turning them counter-clockwise with a 19mm socket wrench.
Шаг 3 · фото 1Шаг 3 · фото 2
3
  • Place jack stand on frame of car and remove jack.
  • Do not work under car supported only by hydraulic jack, serious injury or death may result.
Шаг 3 · фото 1
3
  • Remove tires by pulling directly away from car exposing rear brake disks and calipers.
Шаг 4 · фото 1
4
  • Locate the two 17mm caliper guide bolts.
Шаг 5 · фото 1
5
  • Remove upper and lower guide bolts on rear left and rear right brake calipers with 17mm crescent wrench.
Шаг 6 · фото 1
6
  • Remove rear brake calipers from rotors.
Шаг 7 · фото 1
7
  • Locate the two rear brake pad retaining pins on each caliper.
Шаг 8 · фото 1
8
  • Remove brake pad retaining pins by punching them out with a 3mm allen key.
Шаг 9 · фото 1
9
  • Remove both rear brake pads by pulling them out of calipers.
Шаг 10 · фото 1
10
  • Insert two new brake pads into each caliper.
Шаг 11 · фото 1
11
  • Replace pin guide behind rear brake pads.
Шаг 12 · фото 1Шаг 12 · фото 2
12
  • Verify that pins are inserted through caliper and brake pad holes and seated over the metal pin guides.
Шаг 13 · фото 1
13
  • Tap pins through both rear brake pads and caliper using a wrench.
Шаг 14 · фото 1
14
  • Replace rear calipers on rotors.
Шаг 15 · фото 1Шаг 15 · фото 2Шаг 15 · фото 3
15
  • Finish by performing steps 1-5 in reverse order.

Контент гайда принадлежит iFixit, лицензия CC BY-NC-SA. Открыть оригинал

1985-1988 Volvo 740 Brake Pads Replacement — Carvin Garage · Carvin