1
Make it safe
- Raise the hood.
- Remove the negative terminal clamp from the battery. Should be 10 mm
Chevrolet Windshield Wiper Motor / Transmission Replacement
Remove and replace the windshield wiper transmission assembly which includes the wiper motor
Пошаговая инструкция
2
Mark existing wiper location
- Apply painters tape to the windshield under each wiper arm.
- Use a mark to record the wiper arm position on the windshield
3
Removing the wiper arms
- Remove Antenna, use the proper wrench to loosen the antenna from the base.
- Pull the washer hoses off of the small studs near the wiper arm bases.
- Open the plastic caps from the base of the washer arms, using the proper socket wrench, loosen and remove the hold down nut.
- Remove the washer arms. They make a puller tool but you should be able to wiggle them back and forth and lift them off the stud.
4
Remove the cover grille
- Remove the plastic end covers by prying them off with a wide screw driver
- Remove 2 clips on the front of the plastic grille.
- Remove 2 bolts from each side of the plastic grille.
- Pull up on the grille and disconnect the wiper fluid tube near the drivers fender. there should be a section that will pull apart to allow removal.
5
Remove wiper transmission
- remove three bolts holding the wiper transmission to the body. There should be a rubber gasket on each one - do not remove them from the assembly.
- Remove the power plug, squeeze the plug on the bottom and pull, it should release with little effort.
- Now you have to wiggle the transmission back and forth in the fire wall area in order to get it out
6
Remove Wiper motor
- Using a screwdriver, pry off the linkage from the motor arm.
- Remove three TORX (30) screws which will separate the wiper motor from the wiper transmission.
- NOTE - if you purchase the wiper transmission assembly from a Chevy dealership, it will probably come with a new motor already attached. This means you can skip this step.
7
Reassembly
- Reverse the steps to install the wiper transmission assembly.
Завершение
To reassemble your device, follow these instructions in reverse order.
Контент гайда принадлежит iFixit, лицензия CC BY-NC-SA. Открыть оригинал